Aims. Treatment outcomes for methicillin-resistant Staphylococcus aureus (MRSA) periprosthetic joint infection (PJI) using systemic vancomycin and antibacterial cement spacers during two-stage revision arthroplasty remain unsatisfactory. This study explored the efficacy and safety of intra-articular vancomycin injections for PJI control after debridement and cement spacer implantation in a rat model. Methods. Total knee arthroplasty (TKA), MRSA inoculation, debridement, and vancomycin-spacer implantation were performed successively in rats to mimic first-stage PJI during the two-stage revision arthroplasty procedure. Vancomycin was administered intraperitoneally or intra-articularly for two weeks to control the infection after debridement and spacer implantation. Results. Rats receiving intra-articular vancomycin showed the best outcomes among the four treatment groups, with negative bacterial cultures, increased weight gain, increased capacity for weightbearing activities, increased residual bone volume preservation, and reduced inflammatory reactions in the joint tissues, indicating MRSA eradication in the knee. The vancomycin-spacer and/or systemic vancomycin failed to eliminate the MRSA infections following a two-week antibiotic course. Serum vancomycin levels did not reach nephrotoxic levels in any group. Mild renal histopathological changes, without changes in serum creatinine levels, were observed in the intraperitoneal vancomycin group compared with the intra-articular vancomycin group, but no changes in hepatic structure or serum alanine aminotransferase or aspartate aminotransferase levels were observed. No local complications were observed, such as sinus tract or non-healing surgical incisions. Conclusion. Intra-articular vancomycin injection was effective and safe for PJI control following debridement and spacer implantation in a rat model during two-stage revision arthroplasties, with better outcomes than systemic vancomycin administration. Cite this article: Bone Joint Res 2022;11(6):371–385

Aims. Prompt and sufficient broad-spectrum empirical antibiotic treatment is key to preventing infection following open tibial fractures. Succeeding co-administration, we dynamically assessed the time for which vancomycin and meropenem concentrations were above relevant epidemiological cut-off (ECOFF) minimal inhibitory concentrations (T > MIC) in tibial compartments for the bacteria most frequently encountered in open fractures. Low and high MIC targets were applied: 1 and 4 µg/ml for vancomycin, and 0.125 and 2 µg/ml for meropenem. Methods. Eight pigs received a single dose of 1,000 mg vancomycin and 1,000 mg meropenem simultaneously over 100 minutes and 10 minutes, respectively. Microdialysis catheters were placed for sampling over eight hours in tibial cancellous bone, cortical bone, and adjacent subcutaneous adipose tissue. Venous blood samples were collected as references. Results. Across the targeted ECOFF values, vancomycin displayed longer T > MIC in all the investigated compartments in comparison to meropenem. For both drugs, cortical bone exhibited the shortest T > MIC. For the low MIC targets and across compartments, mean T > MIC ranged between 208 and 449 minutes (46% to 100%) for vancomycin and between 189 and 406 minutes (42% to 90%) for meropenem. For the high MIC targets, mean T > MIC ranged between 30 and 446 minutes (7% to 99%) for vancomycin and between 45 and 181 minutes (10% to 40%) for meropenem. Conclusion. The differences in the T > MIC between the low and high targets illustrate how the interpretation of these results is highly susceptible to the defined MIC target. To encompass any trauma, contamination, or individual tissue differences, a more aggressive dosing approach may be considered to achieve longer T > MIC in all the exposed tissues, and thereby lower the risk of acquiring an infection after open tibial fractures. Cite this article: Bone Joint Res 2022;11(2):112–120

Aims. Periprosthetic joint infections (PJIs) are rare, but represent a great burden for the patient. In addition, the incidence of methicillin-resistant Staphylococcus aureus (MRSA) is increasing. The aim of this rat experiment was therefore to compare the antibiotics commonly used in the treatment of PJIs caused by MRSA. Methods. For this purpose, sterilized steel implants were implanted into the femur of 77 rats. The metal devices were inoculated with suspensions of two different MRSA strains. The animals were divided into groups and treated with vancomycin, linezolid, cotrimoxazole, or rifampin as monotherapy, or with combination of antibiotics over a period of 14 days. After a two-day antibiotic-free interval, the implant was explanted, and bone, muscle, and periarticular tissue were microbiologically analyzed. Results. Vancomycin and linezolid were able to significantly (p < 0.05) reduce the MRSA bacterial count at implants. No significant effect was found at the bone. Rifampin was the only monotherapy that significantly reduced the bacterial count on implant and bone. The combination with vancomycin or linezolid showed significant efficacy. Treatment with cotrimoxazole alone did not achieve a significant bacterial count reduction. The combination of linezolid plus rifampin was significantly more effective on implant and bone than the control group in both trials. Conclusion. Although rifampicin is effective as a monotherapy, it should not be used because of the high rate of resistance development. Our animal experiments showed the great importance of combination antibiotic therapies. In the future, investigations with higher case numbers, varied bacterial concentrations, and changes in individual drug dosages will be necessary to be able to draw an exact comparison, possibly within a clinical trial. Cite this article: Bone Joint Res 2022;11(3):143–151

Aims. There is a lack of biomaterial-based carriers for the local delivery of rifampicin (RIF), one of the cornerstone second defence antibiotics for bone infections. RIF is also known for causing rapid development of antibiotic resistance when given as monotherapy. This in vitro study evaluated a clinically used biphasic calcium sulphate/hydroxyapatite (CaS/HA) biomaterial as a carrier for dual delivery of RIF with vancomycin (VAN) or gentamicin (GEN). Methods. The CaS/HA composites containing RIF/GEN/VAN, either alone or in combination, were first prepared and their injectability, setting time, and antibiotic elution profiles were assessed. Using a continuous disk diffusion assay, the antibacterial behaviour of the material was tested on both planktonic and biofilm-embedded forms of standard and clinical strains of Staphylococcus aureus for 28 days. Development of bacterial resistance to RIF was determined by exposing the biofilm-embedded bacteria continuously to released fractions of antibiotics from CaS/HA-antibiotic composites. Results. Following the addition of RIF to CaS/HA-VAN/GEN, adequate injectability and setting of the CaS/HA composites were noted. Sustained release of RIF above the minimum inhibitory concentrations of S. aureus was observed until study endpoint (day 35). Only combinations of CaS/HA-VAN/GEN + RIF exhibited antibacterial and antibiofilm effects yielding no viable bacteria at study endpoint. The S. aureus strains developed resistance to RIF when biofilms were subjected to CaS/HA-RIF alone but not with CaS/HA-VAN/GEN + RIF. Conclusion. Our in vitro results indicate that biphasic CaS/HA loaded with VAN or GEN could be used as a carrier for RIF for local delivery in clinically demanding bone infections. Cite this article: Bone Joint Res 2022;11(11):787–802

Aims

The efficacy of saline irrigation for treatment of implant-associated infections is limited in the presence of porous metallic implants. This study evaluated the therapeutic efficacy of antibiotic doped bioceramic (vancomycin/tobramycin-doped polyvinyl alcohol composite (PVA-VAN/TOB-P)) after saline wash in a mouse infection model implanted with titanium cylinders.

Aim. The use of bone substitutes such as calcium sulfate (CaSO4) and hydroxyapatite with local antibiotics are crucial in the treatment of osteomyelitis. They allow the treatment of the dead space and locally provide large concentrations of antibiotics. However, it is unknown whether use of local vancomycin may elute and influence on vancomycin plasma levels. The aim of this study is to assess whether the addition of vancomycin to CaSO4 with hydroxyapatite may increase vancomycin plasma concentrations in in patients with osteomyelitis and therefore alter dosage adjustments. Method. The present study investigates the vancomycin plasma concentrations at 72–94 h post-surgery after the application of local vancomycin within CaSO4 (660mg vancomycin/10cc) and hydroxyapatite bone substitute in patients treated with empiric intravenous vancomycin and surgically treated for osteomyelitis. Vancomycin plasma concentrations were analyzed in twelve patients with osteomyelitis surgically treated with local release of vancomycin by CaSO4 and hydroxyapatite and undergoing therapeutic drug monitoring (TDM) of their vancomycin plasma concentrations as it is routinely done in our hospital. From 2019 to 2022, demographic data, microbiology, type of osteomyelitis, amount of local vancomycin applied, alteration of renal function, and vancomycin levels were retrospectively analyzed. Results. Twelve patients were included: 9(75%) were men. Median (range) demographic and clinical data: age: 51(26–67) years; body mass index: 27.7(18–46.4) kg/m2;baseline serum creatinine: 0.85 (0.7–1.24)mg/dl and 5(41.7%) with and glomerular filtration rate < 90ml/min(CPD-EPI, ml/min). Most frequently isolated microorganisms were Staphylococci (58%). Seven (54%) patients were classified as Cierny-Mader Osteomyelitis type III, 3(23%) as type IV and 2(23%) as type I. Treatment data: initial dose of vancomycin: 1g/8h in 9(75.0%) and 1g/12h in 3(25%) patients, total daily dose/body weight: 35.3(15.9–46.2) mg/kg. Pharmacokinetic data:days of iv vancomycin treatment until first TDM measurement: 3(3–4) days; minimum and maximum vancomycin plasma concentrations: 9.4(3–17.3) mg/L and 19.6(11.3–33.4) mg/L, respectively; patients with therapeutic concentrations: 6(50%); infratherapeutic: 4(33.3%) and supratherapeutic/potentially toxic: 2(16.7%). These 2 patients were young, had a baseline conserved renal function and were receiving the higher dose of 1g/8h. Conclusions. Vancomycin incorporated into the bone substitute appears not to increase blood concentrations of the glycopeptide in patients with osteomyelitis treated surgically and with intravenous vancomycin. However, 2 of the 12 patients presented supratherapeutic and potentially nephrotoxic vancomycin concentrations in the first TDM measurement, even though they were young and without renal impairment and needed and unexpected dose reduction. These results suggest the need to confirm the safety of local vancomycin in further larger clinical studies

Topically applied vancomycin powder has been used to decrease surgical site infection rates in spinal surgeries, however, randomized controlled trials in total joint arthroplasty are lacking. Application of vancomycin powder topically in the surgical site has theoretical benefit including high local concentration. In this study, we aimed to determine whether intra-operative topical antibiotics are safe and effective as IV antibiotics in preventing post-surgical site infections. The trial was a randomized controlled, double blind, non-inferiority study. All patients received pre-operative IV antibiotics (cefazolin or vancomycin) within 60 minutes of skin incision. The controlled group received two doses of post-operative IV antibiotics (two grams cefazolin or one gram vancomycin if cefazolin allergy). In the treatment group, the orthopaedic surgeon applied one gram vancomycin powder (500mg applied directly on the prosthesis and 500mg applied above the closed joint capsule). The incidence of acute surgical site infection was defined as positive deep cultures within 42 days of procedure. All patients with evidence of infection underwent joint aspiration for culture. After one year, 80 patients had received the topical vancomycin treatment and 85 patients had received the standard treatment. In the topical vancomycin group versus the controlled group, the average age was 64 vs 66, average BMI was 35.7 vs 33.4, number of males 33 vs 29, number of females 47 vs 56, and diabetic patients 16 vs 13. The number of infections in the topical vancomycin group was three vs zero in the post-operative IV antibiotic treatment group. One Tailed Z-test P Value = 0.03. This study statistically demonstrated inferiority of topical vancomycin in comparison to the use of IV antibiotics post-operatively in preventing deep wound infections in TKA. The authors would caution against the sole use of intra-operative vancomycin in TKA to prevent post-operative infection

Aims. We aimed to determine the concentrations of synovial vancomycin and meropenem in patients treated by single-stage revision combined with intra-articular infusion following periprosthetic joint infection (PJI), thereby validating this drug delivery approach. Methods. We included 14 patients with PJI as noted in their medical records between November 2021 and August 2022, comprising eight hip and seven knee joint infections, with one patient experiencing bilateral knee infections. The patients underwent single-stage revision surgery, followed by intra-articular infusion of vancomycin and meropenem (50,000 µg/ml). Synovial fluid samples were collected to assess antibiotic concentrations using high-performance liquid chromatography. Results. The peak concentrations of vancomycin and meropenem in the joint cavity were observed at one hour post-injection, with mean values of 14,933.9 µg/ml (SD 10,176.3) and 5,819.1 µg/ml (SD 6,029.8), respectively. The trough concentrations at 24 hours were 5,495.0 µg/ml (SD 2,360.5) for vancomycin and 186.4 µg/ml (SD 254.3) for meropenem. The half-life of vancomycin was 6 hours, while that of meropenem ranged between 2 and 3.5 hours. No significant adverse events related to the antibiotic administration were observed. Conclusion. This method can achieve sustained high antibiotic concentrations within the joint space, exceeding the reported minimum biofilm eradication concentration. Our study highlights the remarkable effectiveness of intra-articular antibiotic infusion in delivering high intra-articular concentrations of antibiotics. The method provided sustained high antibiotic concentrations within the joint cavity, and no severe side-effects were observed. These findings offer evidence to improve clinical treatment strategies. However, further validation is required through studies with larger sample sizes and higher levels of evidence. Cite this article: Bone Joint Res 2024;13(10):535–545

Periprosthetic joint infection (PJI) occurs in 0.2-2% of primary hip and knee arthroplasty and is a leading cause of revision surgery, impaired function, and increased morbidity and mortality. Topical, intrawound vancomycin administration allows for high local drug concentrations at the surgical site and has demonstrated good results in prevention of surgical site infection after spinal surgery. It is a promising treatment to prevent infection following hip and knee arthroplasty. Prior studies have been limited by small sample sizes and the low incidence of PJI. This systematic review and meta-analysis was performed to determine the effectiveness of topical vancomycin for the primary prevention of PJI in hip and knee arthroplasty. A search of Embase, MEDLINE, and PubMed databases as of June 2020 was performed according to PRISMA guidelines. Studies comparing topical vancomycin to standard perioperative intravenous antibiotics in primary THA and TKA with a minimum of three months follow-up were identified. The results from applicable studies were meta-analysed to determine the impact of topical vancomycin on PJI rates as well as wound-related and overall complications. Results were expressed as odds ratios (ORs) and 95% confidence intervals. Nine comparative observational studies were eligible for inclusion. 3371 patients treated with 0.5-2g of topical vancomycin were compared to 2884 patients treated with standard care. Only one of nine studies found a significantly lower rate of PJI after primary THA or TKA (OR 0.09-1.97, p=0.04 for one study, p>0.05 for eight of nine studies), though meta-analysis showed a significant benefit, with vancomycin lowering PJI rates from 1.6% in controls to 0.7% in the experimental group (OR 0.47, p=0.02, Figure 1). Individually, only one of five studies showed a significant benefit to topical vancomycin in THA, while none of seven studies investigating PJI after TKA showed a benefit to topical vancomycin. In meta-analysis of our subgroups, there was a significant reduction in PJI with vancomycin in THA (OR 0.34, p=0.04), but there was no significant difference in PJI after TKA (OR 0.60, p = 0.13). In six studies which reported complication rates other than PJI, there were no significant differences in overall complication rates with vancomycin administration for any study individually (OR 0.48-0.94, p>0.05 for all studies), but meta-analysis found a significant difference in complications, with a 6.7% overall complication rate in controls compared to 4.8% after topical vancomycin, largely driven by a lower PJI incidence (OR 0.76, p=0.04). Topical vancomycin is protective against PJI after hip and knee arthroplasty. No increase in wound-related or overall complication rates was found with topical vancomycin. This meta-analysis is the largest to date and includes multiple recent comparative studies while excluding other confounding interventions (such as povidone-iodine irrigation). However, included studies were predominantly retrospective and no randomized-controlled trials have been published. The limited evidence summarized here indicates topical vancomycin may be a promising modality to decrease PJI, but there is insufficient evidence to conclusively show a decrease in PJI or to demonstrate safety. A prospective, randomized-controlled trial is ongoing to better answer this question. For any figures or tables, please contact the authors directly

While pre-soaking grafts in vancomycin has demonstrated to be effective in observational studies for anterior cruciate ligament reconstruction (ACLR) infection prevention, the economic benefit of the technique is uncertain. The primary aim of this study was to determine the cost-effectiveness of vancomycin pre-soaking during primary ACLR to prevent post-operative joint infections. The secondary aims of the study were to establish the breakeven cost-effectiveness threshold of the technique. A Markov model was used to determine cost effectiveness and the incremental cost effectiveness ratio of additional vancomycin pre-soaking compared to intravenous antibiotic prophylaxis alone. A repeated meta-analysis of nine cohort studies (Level III evidence) was completed to determine the odds ratio of infection with vancomycin pre-soaking compared to intravenous antibiotics alone. Estimated costs and transitional probabilities for further surgery were obtained from the literature. Breakeven threshold analysis was performed. The vancomycin soaking technique provides an expected cost saving of $600AUD per patient. There was an improvement in the quality-adjusted life years of 0.007 compared to intravenous antibiotic prophylaxis alone (4.297 versus 4.290). If the infection rate is below 0.023% with intravenous antibiotics alone or the additional intervention cost more than $1000AUD, the vancomycin wrap would no longer be cost-effective. For $30AUD, the vancomycin soaking technique provides a $600AUD cost saving by both reducing the risk of ACLR related infection and economic burden of infection. Treating septic arthritis represents a mean cost per patient of 6 times compared to that of the primary surgery. There has been no previous cost-effectiveness study of the vancomycin wrap technique. The vancomycin pre-soaking technique is a highly cost-effective method to prevent post-operative septic arthritis following primary ACLR

Aim. Vancomycin is frequently used for bone and joint infections (BJI) because of the main role of Gram-positive bacteria as potential causal agents. It is crucial to achieve optimal vancomycin plasma concentrations since the first day to maximize treatment clinical and microbiological efficacy. The aim was to describe the patients’ profile that are more likely to achieve an optimal pharmacokinetic/pharmacodynamics (PK/PD) vancomycin target in the first therapeutic drug monitoring (TDM) sample. Methods. Retrospective study (March 2018-January 2022) in a university hospital including all patients treated with vancomycin for a BJI and undergoing TDM. Initial dose (1g/8-12h) was selected by the responsible clinician. Vancomycin plasma concentrations were obtained pre-dose (Cmin,ss) and 60-minutes after the infusion on day 2 of treatment. Global exposure measured by the area under the curve of plasma concentrations during 24h (AUC024h) was estimated using a bicompartmental PK model. An AUC024h/CMI=400–600mg*h/L was considered optimal, <400 infratherapeutic and >600 supratherapeutic, based on recent guidelines, and patients were classified into these 3 groups. A value of CMI=1 mg/L was considered, following guidelines recommendations. Categorial data: percentages and quantitative data as mean (standard deviation). Results. Ninety-five patients were included: 22(23.2%), 43(45.3%) and 30(31.6%) presented an infratherapeutic, optimal and supratherapeutic PKPD target, respectively. Medium age was 75,8(13,5) in the supratherapeutic group versus 57,2(16,3) in the infratherapeutic group. Weight (kg) was higher in the infratherapeutic group 80,8(18,4) versus 66,8(15,5) in the supratherapeutic group. Vancomycin dose (mg/kg/d) was 43,5(12,4) in the supratherapeutic group versus 34,5(10,8) in the infratherapeutic group. There were 17(56,7) patients who received 1g/8h of vancomycin in the supratherapeutic group and 6 (27,3) in the infratherapeutic group. Baseline glomerular filtration rate (BGF (CKD-EPI) (mL/min/1.73m2) was 71,5(20,1) in the supratherapeutic group and 100,0 (19,9) in the infratherapeutic group. The AUC24h/CMI was 788,0(186,1) in the supratherapeutic group and 323,7(55,4) in the infratherapeutic group. Significant differences observed in age, body weight (BW), baseline renal function and dose/frequency of vancomycin. Dosage adjustments recommendations were made in 62(65.3%) patients: 31(32.6%) dose-increase, 29(30.5%) reduction and 2 cases (2.1%) a temporary suspension. Conclusions. Less than 50% of patients achieved an optimal exposure of vancomycin on day 2 of treatment. Patients with infratherapeutic levels had a younger age and a higher body weight and glomerular filtration rate. In addition, they had received a lower vancomycin initial dose. On the contrary, a potentially toxic exposure was observed within older patients with impaired baseline renal function. These data suggest the relevance of an early vancomycin TDM for optimizing the treatment of BJI

The routine use of intraoperative vancomycin powder to prevent postoperative wound infections has not been borne out in the literature in the pediatric spine population. The goal of this study is to determine the impact of vancomycin powder on postoperative wound infection rates and determine its potential impact on microbiology. A retrospective analysis of the Harms Study Group database of 1269 adolescent idiopathic scoliosis patients was performed. Patients that underwent a posterior fusion from 2004-2018 were analyzed. A comparative analysis of postoperative infection rates was done between patients that received vancomycin powder to those who did not. Statistical significance was determined using Chi-squared test. Additionally, the microbiology of infected patients was examined. In total, 765 patients in the vancomycin group (VG) were compared to 504 patients in the non-vancomycin group (NVG). NVG had a significantly higher rate of deep wound infection (p<0.0001) and associated reoperation rate compared to VG (p<0.0001). Both groups were compared for age, gender, race, weight, surgical time, blood loss, number of levels instrumented, and preop curve magnitude. There were significant differences between the groups for race (p<0.0001); surgical time (p=0.0033), and blood loss (p=0.0021). In terms of microbiology, VG grew p.acnes (n=2), and serratia (n=1), whereas NVG grew p.acnes (n=1) and gram positive bacilli (n=1). The remaining cultures were negative. The use of intraoperative vancomycin powder in adolescent idiopathic scoliosis appears to contribute significantly to deep wound infection prevention and reduction of associated reoperations. Based on this study's limited culture data, Vancomycin does not seem to alter the microbiology of deep wound infections

Aims. The efficacy and safety of intrawound vancomycin for preventing surgical site infection in primary hip and knee arthroplasty is uncertain. Methods. A systematic review of the literature was conducted, indexed from inception to March 2020 in PubMed, Web of Science, Cochrane Library, Embase, and Google Scholar databases. All studies evaluating the efficacy and/or safety of intrawound vancomycin in patients who underwent primary hip and knee arthroplasty were included. Incidence of periprosthetic joint infection (PJI), superficial infection, aseptic wound complications, acute kidney injury, anaphylactic reaction, and ototoxicity were meta-analyzed. Results were reported as odds ratios (ORs) and 95% confidence intervals (CIs). The quality of included studies was assessed using the risk of bias in non-randomized studies of interventions (ROBINS-I) assessment tool. Results. Nine studies involving 4,607 patients were included. Intrawound vancomycin was associated with lower incidence of PJI (30 patients (1.20%) vs 58 control patients (2.75%); OR 0.44, 95% CI 0.28 to 0.69) and simultaneous acute kidney injury (four patients (0.28%) vs four control patients (0.35%), OR 0.71, 95% CI 0.19 to 2.55). However, it did not reduce risk of superficial infection (four patients (0.67%) vs six control patients (1.60%), OR 0.60, 95% CI 0.17 to 2.12) and was associated with higher incidence of aseptic wound complications (23 patients (2.15%) vs eight in control patients (0.96%), OR 2.39, 95% CI 1.09 to 5.23). Four studies reported no anaphylactic reactions and three studies reported no ototoxicity in any patient group. Conclusion. The current literature suggests that intrawound vancomycin used in primary hip and knee arthroplasty may reduce incidence of PJI, but it may also increase risk of aseptic wound complications. Cite this article: Bone Joint Res 2020;9(11):778–788

Objectives. The aim of this study was to analyze drain fluid, blood, and urine simultaneously to follow the long-term release of vancomycin from a biphasic ceramic carrier in major hip surgery. Our hypothesis was that there would be high local vancomycin concentrations during the first week with safe low systemic trough levels and a complete antibiotic release during the first month. Methods. Nine patients (six female, three male; mean age 75.3 years (sd 12.3; 44 to 84)) with trochanteric hip fractures had internal fixations. An injectable ceramic bone substitute, with hydroxyapatite in a calcium sulphate matrix, containing 66 mg of vancomycin per millilitre, was inserted to augment the fixation. The vancomycin elution was followed by simultaneously collecting drain fluid, blood, and urine. Results. The antibiotic concentration in the drain reached a peak during the first six hours post-surgery (mean 966.1 mg/l), which decreased linearly to a mean value of 88.3 mg/l at 2.5 days. In the urine, the vancomycin concentration reached 99.8 mg/l during the first two days, followed by a logarithmic decrease over the next two weeks to reach 0 mg/l at 20 days. The systemic concentration of vancomycin measured in blood serum was low and decreased linearly from 2.17 mg/l at one hour post-surgery to 0 mg/l at four days postoperatively. Conclusion. This is the first long-term pharmacokinetic study that reports vancomycin release from a biphasic injectable ceramic bone substitute. The study shows initial high targeted local vancomycin levels, sustained and complete release at three weeks, and systemic concentrations well below toxic levels. The plain ceramic bone substitute has been proven to regenerate bone but should also be useful in preventing bone infection. Cite this article: M. Stravinskas, M. Nilsson, A. Vitkauskiene, S. Tarasevicius, L. Lidgren. Vancomycin elution from a biphasic ceramic bone substitute. Bone Joint Res 2019;8:49–54. DOI: 10.1302/2046-3758.82.BJR-2018-0174.R2

Aims. Poly(methyl methacrylate) (PMMA)-based bone cements are the industry standard in orthopaedics. PMMA cement has inherent disadvantages, which has led to the development and evaluation of a novel silorane-based biomaterial (SBB) for use as an orthopaedic cement. In this study we test both elution and mechanical properties of both PMMA and SBB, with and without antibiotic loading. Methods. For each cement (PMMA or SBB), three formulations were prepared (rifampin-added, vancomycin-added, and control) and made into pellets (6 mm × 12 mm) for testing. Antibiotic elution into phosphate-buffered saline was measured over 14 days. Compressive strength and modulus of all cement pellets were tested over 14 days. Results. The SBB cement was able to deliver rifampin over 14 days, while PMMA was unable to do so. SBB released more vancomycin overall than did PMMA. The mechanical properties of PMMA were significantly reduced upon rifampin incorporation, while there was no effect to the SBB cement. Vancomycin incorporation had no effect on the strength of either cement. Conclusion. SBB was found to be superior in terms of rifampin and vancomycin elution. Additionally, the incorporation of these antibiotics into SBB did not reduce the strength of the resultant SBB cement composite whereas rifampin substantially attenuates the strength of PMMA. Thus, SBB emerges as a potential weight-bearing alternative to PMMA for the local delivery of antibiotics. Cite this article: Bone Joint Res 2021;10(4):277–284

Anterior cruciate ligament injury is the most common and economically costly sport injuries, frequently requiring expensive surgery and rehabilitation. Post-operative knee septic arthritis represents a serious complication with an incidence rate between 0.14% and 1.7%. A common practice to avoid septic arthritis is the “vancomycin wrap”, consisting in the soaking of the graft for 10–15 minutes within a sterile gauze swab previously saturated with 5 mg/mL vancomycin. Even though several studies have been conducted to investigate vancomycin toxicity on different musculoskeletal tissues or cells, little is known about the effect of such antimicrobial on tendon-derived cells. The aim of this study was to determine the in vitro toxicity of different concentrations of vancomycin at different time points on human primary tenocytes (hTCs). hTCs were isolated from hamstring grafts of patients undergoing anterior cruciate ligament reconstruction. After expansion, cells were treated with different concentrations of vancomycin (2.5, 5, 10, 25, 50 and 100 mg/mL) for 10, 15, 30 and 60 minutes. In vitro toxicity was evaluated measuring: metabolic activity through the reduction of 3-(4,5-Dimethylthiazol-2-yl)-2,5-diphenyltetrazolium bromide (MTT Assay); cytotoxicity (Live/Dead assay); and cell apoptosis (Annexin V apoptosis kit). The metabolic activity of hTCs was affected by vancomycin treatment starting from 10 mg/mL at all time points (p < 0.05) and dropped down at 100 mg/mL at all time points (0.05 < p < 0.001). Cells viability resulted to be unaffected only by 2.5 mg/mL vancomycin at all time points. Vancomycin resulted to be cytotoxic starting from 10 mg/mL after 15 minutes of treatment and at all higher concentrations under study at all time points. Cells died when treated with vancomycin concentrations higher than 5 mg/mL but not through apoptosis, as confirmed by negative staining for Annexin V. In our experimental conditions, vancomycin resulted to be toxic on hTCs at concentrations higher than 5 mg/mL. The use of this antibiotic on tendons to prevent infections could be useful and safe for resident cells if used at a concentration of 2.5 mg/mL up to 1 hour of treatment

Aim. The rise of multidrug-resistant bacteria and the decreasing efficacy of antibiotic therapy in successfully treating biofilm-associated infections are prompting the exploration of alternative treatment options. This study investigates the efficacy of different bioactive glass (BAG) formulations - alone or combined with vancomycin - to eradicate biofilm. Further, we study the influence of BAG on pH and osmotic pressure as important factors limiting bacterial growth. Method. Different BAG-S53P4 formulations were used for this study, including (a) BAG-powder (<45 μm), (b) BAG-granules (500–800 μm), (c) a cone-shaped BAG-scaffold and (d) two kinds of BAG-putty containing granules, with no powder (putty-A) or with additional powder (putty-B), and a synthetic binder. Inert glass beads were included as control. All formulations were tested in a concentration of 1750 g/ml in Müller-Hinton-Broth. Targeted bacteria included methicillin-resistant Staphylococcus aureus (MRSA) and epidermidis (MRSE). Vancomycin was tested at the minimum-inhibitory-concentration for each strain (1 µg/ml for MRSA; 2 μg/ml for MRSE). To investigate the antibiofilm effect of BAG alone or combined with vancomycin, 3 hour-old MRSA or MRSE biofilms were formed on porous glass beads and exposed to BAG ± vancomycin for 24h, 72h and 168h. After co-incubation, biofilm-beads were deep-washed in phosphate-buffered saline and placed in glass vials containing fresh medium. Recovering biofilm bacteria were detected by measuring growth-related heat production at 37°C for 24h by isothermal microcalorimetry. Changes in pH and osmotic pressure over time were assessed after co-incubation of each BAG formulation in Müller-Hinton-Broth for 0h, 24h, 72h and 168h. Results. All BAG formulations showed antibiofilm activity against MRSA and MRSE in a time-dependent manner, where longer incubation times revealed higher antibiofilm activity. BAG-powder and BAG-putty-B were the most effective formulations suppressing biofilm, followed by BAG-granules, BAG-scaffold and finally BAG-putty-A. The addition of vancomycin had no substantial impact on biofilm suppression. An increase in pH and osmotic pressure over time could be observed for all BAG formulations. BAG-powder reached the highest pH value of 12.5, whereas BAG-putty-A resulted in the lowest pH of 9. Both BAG-putty formulations displayed the greatest increase on osmotic pressure. Conclusions. BAG-S53P4 has demonstrated efficient biofilm suppression against MRSA and MRSE, especially in powder-containing formulations. Our data indicates no additional antibiofilm improvement with addition of vancomycin. Moreover, high pH appears to have a larger antimicrobial impact than high osmolarity. Acknowledgements. This work was supported by PRO-IMPLANT Foundation (Berlin, Germany). The tested materials were provided by Bonalive Biomaterials Ltd (Turku, Finland)

Aim. Bacteriophages are remerging as alternative and adjunctive therapy for fracture-related infection (FRI). However, current administration protocols involve prolonged retention of a percutaneous draining tube with potential risk of developing superinfection. In this study, we applied a cocktail of in vitro evolved biofilm-targeting phages for Methicillin-resistant Staphylococcus aureus (MRSA) in a hydrogel platform co-delivering vancomycin. In vitro synergy and antibiofilm activity was assessed and a subsequent in vivo study was performed in a mouse FRI model with MRSA. Method. Two evolved bacteriophages (MRSA-R14 and COL-R23) with improved antibiofilm activity against a clinical isolate (MRSA3) were tested in combination with vancomycin and a carboxymethylcellulose (CMC) hydrogel in vitro and in vivo. MRSA3 bacterial biofilms were formed on sterile 4 mm sintered porous glass beads at 37 °C for 24 h. Biofilms were exposed to i-phage cocktail (10. 7. PFU/ml), ii-vancomycin at concentrations of 0.5, 1, 10 and 100 times the MIC, or iii-combination of phage cocktail and vancomycin. Recovered biofilm cells, were quantified by colony counting. The stability and release profiles of phage cocktail and vancomycin in co-delivery hydrogel were assessed in vitro for 8 days and 72 hrs, respectively, and subsequently tested in the treatment of 5-day-old MRSA3 infection of a femoral plate osteotomy in mice. Results. In vitro: The cocktail of evolved phages (10. 7. PFU/ml, 1:1) combined with 0.5 MIC vancomycin achieved 99.72% reduction in MRSA3 biofilm in vitro compared to the growth control. This combination was stable in the co-delivery hydrogel over 8 days. The release profile showed that 57% of phages and 80% of vancomycin were released after 72hrs, which was identical to the performance for gels loaded with phage or antibiotic alone. In the in vivo study, the bacterial load from animals that received co-delivery hydrogel and systemic vancomycin was significantly reduced compared to controls, animals that received systemic vancomycin and animals that received co-delivery hydrogel alone (p<0.05). Conclusions. Our study demonstrates the potential of using evolved phages in combination with vancomycin and hydrogel delivery systems for the treatment of MRSA-related infections. Further research in this area may lead to the development of specific therapies for biofilm-related infection

There is an increasing incidence of revision for periprosthetic joint infection. The addition of vancomycin to beta-lactam antimicrobial prophylaxis in joint arthroplasty may reduce surgical site infections, however, the efficacy and safety have not been established. This was a multicenter, double-blind, superiority, placebo-controlled trial. We randomized 4239 adult patients undergoing joint arthroplasty surgery to receive 1.5g vancomycin or normal saline placebo, in addition to standard cefazolin antimicrobial prophylaxis. The primary outcome was surgical site infection at 90-days from index surgery. Perioperative carriage of Staphylococcus species was also assessed. In the 4113 patients included in the modified intention-to-treat population, surgical site infections occurred in 72/2069 (3.5%) in the placebo group and 91/2044 (4. 5%) in the vancomycin group (risk ratio 1.28; 95% confidence interval 0.94 to 1.73; p value 0.11). No difference was observed between the two groups for primary hip arthroplasty procedures. A higher proportion of infections occurred in knee arthroplasty patients in the vancomycin group (63/1109 [4.7%]) compared with the placebo group (42/1124 [3.7%]; risk ratio 1.52; 95% confidence interval 1.04 to 2.23; p value 0.031). Hypersensitivity reactions occurred in 11 (0.5%) patients in the placebo group and 24 (1.2%) in the vancomycin group (risk ratio 2.20; 95% confidence interval 1.08, 4.49) and acute kidney injury in 74 (3.7%) patients in the placebo group and 42 (2.1%) in the vancomycin group (risk ratio 0.57; 95% confidence interval 0.39, 0.83). Perioperative Staphylococcus aureus carriage was detected in 1089/3748 (29.1%) of patients. This is the first randomized controlled trial examining the addition of a glycopeptide antimicrobial to standard beta-lactam surgical antimicrobial prophylaxis in joint arthroplasty. The addition of vancomycin to standard cefazolin prophylaxis was not superior to placebo for the prevention of surgical site infections in hip and knee arthroplasty surgery

Aim. Local antibiotics, delivered to the site of infection, achieve high tissue concentrations and are used as an adjunct to systemic therapy. Local gentamicin provides levels well above the minimum inhibitory concentration and may be sufficient on its own, however, the efficacy of single or combination local antibiotics has not been studied. This retrospective study evaluated the effect of combination aminoglycoside and vancomycin local antibiotic treatment compared to aminoglycoside alone in the surgical management of bone infection. Method. We studied patients with microbiologically confirmed osteomyelitis and fracture-related infection, who had implantation of antibiotic carriers as part of their surgical management. Data including patient demographics, type of surgery, microbiological characteristics, BACH score, duration of antibiotic treatment and clinical outcomes were collected. Failure of therapy was a composite of recurrence of infection, continued or new antimicrobial therapy, or reoperation with suspected or confirmed infection at one year after index surgery. Results. There were 266 patients who met the inclusion criteria. Nine patients died before the outcome endpoint at 12 months and five patients were lost to follow up so were excluded. 252 patients were included in the final analysis and were well matched with regard to demographics, BACH score and microbiology. 113 patients had treatment with aminoglycoside alone and 139 patients had combination aminoglycoside and vancomycin. There was no difference in the failure rate between groups; 10/113 (8.8%) in the aminoglycoside alone and 12/139 (8.6%) in the combination group, p = 0.934. There was no difference for reoperation, ongoing suppressive antibiotic use, or clinical suspicion of infection. Multivariate analysis showed that there was no added benefit of combination therapy (OR 1.54: 95%CI 0.59-4.04, p=0.38). BACH score and low BMI were associated with increased risk of failure (BACH OR 3.49: 95%CI 1.13-10.76, p=0.03; Low BMI OR 0.91: 95%CI 0.84-0.99, p-0.037). The form of the carrier material (pellets or injectable paste) had no effect on failure rate (p=0.434). Aminoglycoside resistance (confirmed and presumed) occurred in 39/113 (34.5%) of the aminoglycoside only group and 36/139 (25.9%) of the combination group (p=0.137). The presence of aminoglycoside resistance had no effect on failure rate (OR 0.39: 95%CI 0.05-3.01, p=0.37). Conclusions. Clinical outcome was not improved by the addition of vancomycin to aminoglycoside alone as local therapy for the management of osteomyelitis and FRI. Laboratory measured resistance, using currently accepted breakpoints, may not be relevant in local therapy