Introduction. Osteomyelitis is a challenge in diagnosis and treatment. 18F-FDG PET-CT provides a non-invasive tool for diagnosing and localizing osteomyelitis with a sensitivity reaching 94% and specificity reaching 100%. We aimed to assess the agreement in identifying the geographic area of infected bone and planned resection on plain X-ray versus 18F-FDG PET-CT. Materials & Methods. Clinical photos and X-rays of ten osteomyelitis patients were shown to ten consultant surgeons; they were asked to draw the area of infection and extent of planned surgical debridement; data will be compared to 18F-FDG PET-CT results. Results. We tested the agreement between the surgeons in every parameter. Regarding height, there was poor agreement between surgeons. Regarding perimeter, the ten surgeons showed low-moderate agreement. The ten surgeons showed a low-moderate agreement for circularity. Results document the variability of assessment and judgement based on plain X-rays. In comparison to PET-CT, All parameters were significantly different in favour of 18F-FDG PET-CT over X-ray (P < 0.001). Conclusions. 18F FDG PET-CT provides a three-dimensional tool for localizing the exact location of the infected bone and differentiating it from the normal bone. Thus, it could be beneficial in precise pre-operative planning and surgical debridement of chronic osteomyelitis

Aim. infected segmental bone defect (ISBD) is frequent in developing countries. The aim of this study was to assess the efficacy of the Masquelet technique in the treatment of ISBD in a low-resource setting. Patients and Method. We performed a prospective cohort study during the period from 2018 to 2022. Patients with infected bone defect of long bones were included. Management protocol consisted of two stages in all patients. The first stage consisted in debridement, tissues biopsy for microbiological culture, stabilization with external fixator and defect filling with gentamicin cement spacer. The second stage consisted of reconstruction using a cancellous bone autograft alone, or a mixture of autograft with allograft (demineralized bone matrix + tricalcium phosphate) and 1 gram of vancomycin powder. All patients were followed-up for at least one year. The results were assessed based on both objective (clinical and radiographic evaluation) and subjective (limb function and patient satisfaction) criteria. Main outcomes were bone union, reoperation and failure rates, union time, and limb function. Results. We included 31 patients in this study (80.6% men), with a median age of 35 [9 – 80] years. The tibia was affected in 12 cases and the femur in 15 cases. The median size of bone defect was 4 [1.5 – 12] cm. The most prevalent microorganisms were Klebsiella pneumoniae and Staphylococcus aureus. The mean interval between both stages was 14 (8 – 36) weeks and the median follow-up period after the second stage was 20 [12-62] months. External fixation was used in both stages in 25(80%) cases. Bone union was achieved in 26 (83.8%) patients of whom 24 without recurrence of infection, over a median time of 9 [6 – 16] months. All patients with a mixed graft (allograft and autograft) impregnated with local antibiotics achieved bone union. Two patients needed reoperation for relapse of infection between both stages, and subsequently achieved bone union without recurrence of infection. There were three cases of failure related to persistent infection or insufficient fixation stability in the second stage. Conclusions. Masquelet technique is a reliable procedure that can be safely performed in limited resources settings with satisfactory results. The mixture of autograft and allograft when available, all mixed with vancomycin seems to give promising results

Introduction. We present a case of a 49-year-old patient who initially presented in May 2020 with an open pilon fracture. Managed with initial debridement, fixation and flap - who subsequently underwent circular frame application for failure of fixation, requiring a transport to fusion frame who developed beta-haemolytic streptococcus A within the site of the proximal corticotomy. Materials & Methods. A systematic review of the literature was conducted searching EMBASE, MEDLINE and Cochrane library for all articles discussing infected bone regenerate- a paucity of information was found. Abstracts were independently reviewed by 2 authors (LH and LT). In total, there were 16 papers, and then subsequently analysed we identified two case reports regarding infected regenerate. Results. Developing an infection in a regenerate is highly rare with very few reported cases within the published literature. The literature identified risk factors for an infected regenerate, with open fracture and smoking being the two consistent factors. The open fracture deep infection rate is cited at 10% in most publications, this is at the site of the open fracture and not within the regenerate. Conclusions. Infection within the regenerate during distraction osteogenesis is highly unusual, with only two other published papers in the literature to the best of our knowledge. This should be borne in mind when managing patients with infection of unknown sources in cases of distraction osteogenesis

Prosthetic joint infection (PJI) is a complex disease that causes significant damage to the peri-implant tissue. Developing an animal model that is clinically relevant in depicting this disease process is an important step towards developing novel successful therapies. In this study, we have performed a thorough histologic analysis of peri-implant tissue harvested post Staphylococcus aureus (S. aureus) infection of a cemented 3D-printed titanium hip implant in rats. Sprague-Dawley rats underwent left hip cemented 3D-printed titanium hemiarthroplasty via posterior approach under general anesthesia. Four surgeries were performed for the control group and another four for the infected group. The hip joint was inoculated with 5×10. 9. CFU/mL of S. aureus Xen36 prior to capsule closure. The animals were scarified 3 weeks after infection. The femur was harvested and underwent micro-CT and histologic analysis. Hematoxylin and eosin (H&E), as well as Masson's trichrome (MT) stains were performed. Immunohistochemistry (IHC) using rabbit antibody for S. aureus was also used to localize bacterial presence within femur and acetabulum tissue . The histologic analysis revealed strong resemblance to tissue changes in the clinical setting of chronic PJI. IHC demonstrated the extent of bacterial spread within the peri-implant tissue away from the site of infection. The H&E and MT stains showed 5 main features in infected bone: 1) increased PMNs, 2) fibrovascular inflammation, 3) bone necrosis, and 4) increased osteoclasts 5) fibrosis of muscular tissue and cartilage. Micro CT data showed significantly more osteolysis present around the infected prosthesis compared to control (surgery with no infection). This is the first clinically relevant PJI animal model with detailed histologic analysis that strongly resembles the clinical tissue pathology of chronic PJI. This model can provide a better understanding of how various PJI therapies can halt or reverse peri-implant tissue damage caused by infection

Background and aim. In 2019, specific diagnostic and antibiotic treatment recommendations for diabetic foot infection (DFI) and osteomyelitis (DFO) were introduced in our institution. They include principles on numbers of biopsies to obtain for microbiological/histopathological examinations, labeling anatomic localization, and antibiotic treatment (ABT) duration based on the aforementioned findings. ABT should be stopped after complete resection of infected bone. In case of incomplete resection, treatment is continued for 4–6 weeks. Two years after the introduction of these recommendations, we investigated the degree of implementation for hospitalized patients. Method. Adult patients with DFI/DFO undergoing surgical intervention from 01/2019–12/2021 were reviewed retrospectively. Diagnostic procedures were assigned to each episode when performed ≤30 days before surgical invention. Chi-square and Mann-Whitney-U tests were performed where appropriate. Results. We included 80 patients with 117 hospital episodes and 163 surgical interventions (mean 1.5 episodes and 2 interventions per patient). The mean age was 69.6 (SD 11.5) years, 75% were male. Vascular examination and MRI were performed in 70.9% and 74.4% of episodes, respectively. Impaired perfusion and DFO were confirmed in 34.9% and 56.3%, respectively. Blood cultures were sampled in 34.2%, bacteremia detected in 7.7% with S. aureus being the most common microorganism. Biopsies were obtained in 71.8% of operations, in 90.5% of those 3–5 samples. These were sent for histological examination in 63.2% of the interventions. In 43.6% the anatomic location was labeled ‘proximal to the resection margin’. Preoperative antibiotics were administered in 41.9% of the episodes because of concomitant soft-tissue infections. The most commonly used compound was amoxicillin/clavulanate (74.4%). ABT duration varied significantly when there were signs of DFO in preoperative MRI (p=0.015). The mean duration of antibiotic therapy was 9 (IQR 5–15) days in surgically cured episodes and 40.5 (IQR 15–42) days in cases with resection margins in non-healthy bone (p<0.0001). The results were similar when analyzing treatment duration with respect to osteomyelitis in histology: 13 (IQR 8–42) versus 29 (IQR 13–42) days, respectively (p=0.026). Conclusions. The adherence to recommendations in terms of biopsy sampling was excellent, moderate for sending samples to histology and poor for labeling the anatomic location. The adherence to ABT duration was good but can be improved by shortening treatment duration for surgically cured cases. Results of preoperative MRI appear to be influential on the decision-making for treatment duration

Aim. Chronic osteomyelitis (OM) is usually treated with surgical excision of infected bone and subsequent dead space management to prevent local recurrence. We report outcome after antibiotic loaded biocomposite (ALB). 1. for management of infected bone defects. Method. We report a consecutive series of 97 patients with chronic OM treated at one institution by a multidisciplinary team, using a single-stage revision protocol inspired by a recently published study. 2. . The treatment protocol includes surgical debridement, tissue sampling, dead-space management using the ALB, stabilization and empirical antibiotic therapy adjusted based on culturing. Closure was performed directly, with a local flap, a free flap or secondarily. This series includes all patients operated using the ALB at our institution, since its implementation 26 months ago. The senior author (HG) performed 65 (67%) of the operations. The remaining procedures were performed by 14 different surgeons. Results. Mean age was 66.2 years (26 to 92). In 41 patients, OM followed an overlying soft-tissue infection, 30 followed surgical management of a closed fracture in the affected bone, 18 followed elective surgical procedures in the area, 5 followed open fractures of the affected bone, 2 were spontaneous following bacteremia and 1 patient had previously been diagnosed with OM in the affected bone. Seventy one (73,2%) of the included patients had systemic comorbidities (Cierny-Mader Class B hosts), thirty eight were diabetics, twenty-three were active smokers and twenty-five had a past history of smoking, fourteen consumed alcohol in quantities constituting alcohol abuse and 9 had a previous history of alcohol abuse. Patients were followed-up by chart review for a mean of 5.8 months (0 to 25). Twelve patients required a soft-tissue revision after a mean time of 2.2 months (0 to 12). Eleven patients required bone revision after a mean time of 3.4 months (0 to 10) where the ALB was re-applied in nine cases. Six patients required amputation after a mean time of 3.2 months (0 to 12). Two patients died after a 1 and 5 months respectively. Seventy patients (73%) had no adverse advents following surgery. Conclusions. An acceptable outcome was obtained considering a heterogeneous population with a high comorbidity rate and considerable smoking and alcohol abuse

Aim. Infections in long bones can be divided in osteitis, osteomyelitis and septic non-unions. All are challenging situations for the orthopaedic surgeon. Treatment is a mix with debridement, radical resection of infected tissue, void filling with different types of products, and antibiotic therapy of different kinds. In cavitary bone defects, bioglasses such as BAG-S53P4 have given good results in early or mid-term follow-up. Results of such treatment in segmental bone defects remain unknown. The goal of our study was to evaluate efficacity of active bioglass BAG-S53P4 in septic segmental bone defects. Method. A retrospective cohort study has been done in a single specific orthopaedic center devoted to treatment of infected bony situations. All cases were a severe septic bone defect. We have compared the segmental bone defects to the cavitary ones. Results were analyzed on recurrence of infection, bone healing, functional result and complication rate. Results. 14 patients were included with a minimum follow-up of 1 year after treatment. 8 were in the group “cavitary”, 6 in the group “segmental”. The mean age was 54 years-old (30–76). Sex-ratio was 2.5. All patients have been treated with bone resection and debridement of infected bone and tissue, even if more than 1 surgery was necessary in some cases. After cleaning, 7 patients have needed a local flap, and 1 a free flap. Then, all bone defects were filled up by bioglass BAG-S53P4*. Additional antibiotherapy with specific molecules based of the results of bacterial analysis, was given for a minimum time-period of 6 weeks. In the “cavitary” group, the mean volume of BAG-S53P4 was de 21.25 ml (10–60). In the “segmental” group, it was of 12.5 ml (10–20). The healing rate was of 80% in the “cavitary” group and of 100% in the “segmental” one. No complication related to the bioglass insertion was noted. Conclusions. Different publications have been made using bioglass in the treatment of infected bone with a continuous bone such as osteitis or osteomyelitis. Our study is the first one to compare specifically the results obtained in a cavitary defect where the bone is still in continuity, and in a segmental defect. Active bioglass such as the BAG-S53P4 seems to be a good option in the treatment of segmental septic bone defects in the limb. *BonAlive Biomaterials Ltd, Turku, Finland

Aims

The standard of wide tumour-like resection for chronic osteomyelitis (COM) has been challenged recently by adequate debridement. This paper reviews the evolution of surgical debridement for long bone COM, and presents the outcome of adequate debridement in a tertiary bone infection unit.

Aim. Local concentration of antibiotic at the site of infection is a major parameter for its efficiency. However, bone diffusion is poor leading either to their non-use (ex: gentamicin) or the use of high concentration (ex: vancomycin). Local administration could optimize their local concentration combined with lower side effects. We report the clinical experience and pharmacological results of an antibiotic loaded porous alumina used to replace infected bone in 4 patients. Method. Two patients had a destroyed sternum following mediastinitis; one presented a femoral chronic osteomyelitis due to MRSA and one had an infected ankle arthroplasty. The ceramic was loaded with gentamicin in three cases and vancomycin for the ankle infection. Local dosages thanks to Redon's drain and blood samples were performed. Loading was done to protect the device while implanted in an infected area and was combined with conventional antibiotic therapy. Results. In comparison to pharmacological parameters: C. max. /MIC>8 for gentamicin or AUC/MIC>400 for vancomycin, local concentrations were dramatically higher than the one needed (table). Vancomycin concentration was still high after H48. Meanwhile, blood samples didn't find the presence of gentamicin during the 48 hours following implantation. After more than one year of follow-up for all the patients, there is no relapse of infection or signs of device infection, whereas all samples perform during implantations grew with bacteria, meaning that loaded antibiotic played a major role avoiding device colonization in combination with surgical debridement and cleaning. Conclusions. This mode of administration allows an optimization of the antibiotic delivery, maximizing local concentrations while reducing systemic toxicity. In addition, ceramic mechanical characteristics allow bone replacement (strength >3 times the one of the cancellous bone and osseointegration) and thus enables one-stage surgery instead of two-stage like for the patient with chronic osteomyelitis thanks to a good primary stability. For any figures or tables, please contact the authors directly

Aims. Chronic osteomyelitis may recur if dead space management, after excision of infected bone, is inadequate. This study describes the results of a strategy for the management of deep bone infection and evaluates a new antibiotic-loaded biocomposite in the eradication of infection from bone defects. Patients and Methods. We report a prospective study of 100 patients with chronic osteomyelitis, in 105 bones. Osteomyelitis followed injury or surgery in 81 patients. Nine had concomitant septic arthritis. 80 patients had comorbidities (Cierny-Mader (C-M) Class B hosts). Ten had infected nonunions. All patients were treated by a multidisciplinary team with a single-stage protocol including debridement, multiple sampling, culture-specific systemic antibiotics, stabilisation, dead space filling with the biocomposite and primary skin closure. . Results. Patients were followed up for a mean of 19.5 months (12 to 34). Infection was eradicated in 96 patients with a single procedure and all four recurrences were successfully managed with repeat surgery. Adverse events were uncommon, with three fractures, six wound leaks and three unrelated deaths. Outcome was not dependant on C-M host class, microbial culture, wound leakage or presence of nonunion. Conclusion. This single-stage protocol, facilitated by the absorbable local antibiotic, is effective in the treatment of chronic osteomyelitis. It offers a more patient-friendly treatment compared with other published treatment options. Cite this article: Bone Joint J 2016;98-B:1289–96

Aim. Antibiotic-loaded biomaterials are often used in dead space management after excision of infected bone. This study assessed the chronological progression of new bone formation in infected defects, filled only with an absorbable, osteoconductive bone void filler with Gentamicin (1). Method. 163 patients were treated for osteomyelitis or infected fractures with a single-stage excision, implantation of antibiotic carrier, stabilisation and wound closure. All had Cierny & Mader Type III (n=128) or Type IV (n=35) infection. No bone grafting was performed in any patient. Patients were followed up for a minimum of 12 months (mean 21.4 months; 12–56). Bone void filling was assessed on serial digitised, standardized radiographs taken immediately after surgery, at 6 weeks, 3, 6 and 12 months and then yearly. Data on defect size, location, degree of void filling, quality of the bone-biomaterial interface and material leakage were collected. Bone formation was calculated at final follow-up, as a percentage of initial defect volume, by determining the bone area on AP and lateral radiographs to the nearest 5%. Results. 138 patients had adequate radiographs for assessment. Infection was eradicated in 95.7%. 2.5% of patients suffered a fracture during follow-up. Overall, bone formation was good (mean 73.8% defect filling), with one quarter of patients having complete defect filling and 87% having more than 50% of the defect healed. Bone formed better in metaphyseal defects compared to diaphyseal defects (mean 79% filling vs 66%; p<0.02). Good interdigitation of the biomaterial with the host bone, seen on the initial radiograph, was associated with more bone formation (77% vs 69%; p=0.021). Leakage of the biomaterial out of the defect reduced mean bone formation from 77% to 62% (p=0.006). 38 cases had radiographs more than 2 years after implantation. In 24 (63.2%), bone formation continued to increase after the first year radiograph. Conclusion. This biomaterial was effective in allowing significant amounts of bone to form in the defect. This removed the need for bone grafting in this series, with a low risk of fracture or recurrent infection. However, bone formation is affected by the site of the lesion and the adequacy of filling at surgery. It is important to achieve good contact between the bone surface and the biomaterial at operation. Bone formation is slow and progresses for at least 2 years after implantation, in two thirds of patients

Aim. The aim of this work was to evaluate, via foot and ankle TC scans, the outcomes of the use of a bone substitute (CERAMENT|™G) and the growth of native bone in the treatment of osteomyelitis (OM) of the diabetic foot. Method. In nine patients from July 2014 to December 2016 we used a Calcium Sulphate Hemihydrate + Hydroxyapatite + Gentamicin Sulfate (CSH + HA + GS) compound to fill resected bone voids following surgical intervention in OM diabetic foot cases. Of these nine patients, three were female and six were male and their ages were between 49 and 72 years. Four patients had hindfoot involvement and underwent partial calcanectomy. Two patients presented a rocker-bottom Charcot foot pattern III according to Sanders and Frykberg's classification and were treated with esostectomy of the symptomatic bony prominence of the midfoot. One patient presented OM of the 3°, 4° and 5° metatarsal bones. One patient underwent partial resection of the midfoot and hindfoot with arthrodesis stabilised by an internal-external hybrid fixator. One patient with a Charcot foot pattern IV-V underwent partial talectomy and calcanectomy with arthrodesis stabilised by an internal-external hybrid fixator. In all these patients - after removal of the infected bone - we applied 10 to 20 ml CSH + HA + GS filling the residual spaces with the aim of stabilising the remaining bone fragments. The uniqueness of this product is that it induces native bone growth, while the synthetic bone disappears and antibiotic is released into the surrounding tissues. In March 2018, the above nine patients underwent foot and ankle TC scans to evaluate bone growth. Results. The first four patients showed new bone formation in the calcaneus. Two patients with previous midfoot destruction showed chaotic but stable bone formation. The patient with metatarsal OM showed partial bone healing with residual pseudoarthrosis. Both the two patients who underwent arthrodesis with hybrid fixators showed a plantigrade and stable foot even though a heel wound is still present in one of the patients. All patients except this one are now wearing suitable shoes as post-operative wounds have healed. The patient still with the heel wound is walking with an aircast brace. Conclusion. The TC scans have shown new bone formation sufficient to stabilise the foot and allow ambulation. In particular, very good results come from the filling of the calcaneus, probably due to the anatomy of the bone itself

Aim. Simultaneous use of Ilizarov techniques with transfer of free muscle flaps is not current standard practice. This may be due to concerns about duration of surgery, clearance of infection, potential flap failure or coordination of surgical teams. We investigated this combined technique in a consecutive series of complex tibial infections. Method. A single centre, consecutive series of 45 patients (mean age 48 years; range 19–85) were treated with a single stage operation to apply an Ilizarov frame for bone reconstruction and a free muscle flap for soft-tissue cover. All patients had a segmental bone defect in the tibia, after excision of infected bone and soft-tissue defects which could not be closed directly or with local flaps. We recorded comorbidities, Cierny-Mader and Weber-Cech classification, the Ilizarov method used, flap type, follow-up duration, time to union and complications. Results. 26 patients had osteomyelitis and 19 had infected non-union. Staphylococci were cultured in 25 cases and 17 had polymicrobial infections. Ilizarov monofocal compression was used in 14, monofocal distraction in 15, bifocal compression/distraction in 8, and bone transport in 8. 8/45 had an additional ankle fusion, 7/45 had an angular deformity corrected at the same time and 24 also had local antibiotic carriers inserted. Median time in frame was 5 months (3–14). 38 gracilis, 7 latissimus dorsi and 1 rectus abdominus flaps were used. One flap failed within 48 hours and was revised (flap failure rate 2.17%). There were no later flap complications. Flaps were not affected by distraction or bone transport. Mean follow-up was 23 months (10–89). 44/45 (97.8%) achieved bony union. Recurrence of infection occurred in 3 patients (6.7%). Secondary surgery was required to secure union with good alignment in 8 patients (17.8%; docking site surgery in 6, IM nailing in 2) and in 3 patients for infection recurrence. All were infection free at final follow-up. Conclusions. Simultaneous Ilizarov reconstruction with free muscle flap transfer is safe and effective in treating segmental infected tibial defects, and is not associated with an increased flap failure rate. It shortens overall time spent in treatment, with fewer operations per patient. However, initial theatre time is long and a committed multidisciplinary team is required to achieve good results

Introduction. Septic knee arthritis with severe osteoarthritis (OA) presents challenging clinical situations because of unexpected and long time for treatment and less satisfactory clinical outcomes. Septic arthritis with damage to articular cartilage developed osteomyelitis (OM) frequently. Although arthroscopic debridement was the common treatment of septic arthritis, there was some limitation on the management of infected bone structures and then open arthrotomy should be reserved. In the patients of OM located only periarticular areas, the author used the PROSTALAC system for infected total knee arthroplasty (TKA) and achieved good results. Objectives. In periarticular OM with septic knee arthritis in patients with severe OA, we report the rate of control of infection using the PROSTALAC articulating spacer and to assess the clinical outcome after staged TKA. Methods. This study was conducted on a total of 11 patients (11 knees) treated for septic knee arthritis in patients with Kellgren-Lawrence classification grade 3–4 OA between April, 2014 and April, 2015. Of these, we retrospectively reviewed 6 knees of 6 patients (54.5%) who underwent staged TKA using the PROSTALAC articulating spacer. The inclusion criteria were periarticular OM confirmed by magnetic resonance imaging (MRI) and whole body bone scan (WBBS), affected bone could be resected and covered by the PROSTALAC system. There were 2 males and 4 females with a mean age of 64 years (range, 61 to 68 years). Prior to the initial surgery, the average erythrocyte sedimentation rate (ESR) 87mm/h, and C-reactive protein (CRP) 8.8 mg/dl. The mean follow-up period was 14 months (range, 12 to 24 months). For clinical assessment, WOMAC, UCLA, Patient Satisfaction scores and postoperative complications were evaluated. For radiological assessment, weight-bearing radiographs of the knee were obtained to evaluate bone change, component loosening, and recurrence of infection. Results. The mean interval between initial operation using the PROSTALAC system and staged TKA was 8.2 weeks (range, 8–10 weeks). The species could be identified in the culture of aspiration of joint fluid prior to the initial operation. The most frequently found etiologic agent was gram-positive cocci (66.6%), followed by MRSA (16.7%) and yeast like fungi (16.7%). At last review, ESR and CRP returned to normal and follow-up cultures were negative in all patients. We observed improvements in mean WOMAC, UCLA, and Patient Satisfaction scores at last review. Radiographs at final follow-up showed well-fixed implants with no radiographic evidence of loosening or infection. Conclusions. In this study, we observed a 100% microbiologic cure and 89% clinical cure in patients who underwent a staged TKA using the PROSTALAC system with a 14-months follow-up. This method appears to have several important advantages (1) there is less possibility of additional bone resection due to uncontrolled infection of adjacent bone; (2) there are possibly expected interval between two stages and more good patient satisfaction. The staged TKA using the PROSTALAC spacer would have a predictable, favorable effect on the control of infection and improvements in the functional outcomes for the treatment periarticular OM with septic knee arthritis in patients with severe arthritis

Aims

The STRYDE nail is an evolution of the PRECICE Intramedullary Limb Lengthening System, with unique features regarding its composition. It is designed for load bearing throughout treatment in order to improve patient experience and outcomes and allow for simultaneous bilateral lower limb lengthening. The literature published to date is limited regarding outcomes and potential problems. We report on our early experience and raise awareness for the potential of adverse effects from this device.

Bone and joint infections of the lower limbs cause significant morbidity for patients. Infection is a devastating complication for prosthetic joint replacements. In this large case series from a single centre in the NE of England, we present our experience of using antibiotic impregnated dissolvable synthetic pure calcium sulphate beads [Stimulan R]1 for local elution of antibiotics at the site of infection. At our centre, from August 2012 to Jan 2015, antibiotic impregnated dissolvable synthetic pure calcium sulphate beads [Stimulan R]1 was used for local elution of antibiotics in 45 patients with lower limb bone or joint infections. Tailored plans were made by Orthopedic surgeon and Microbiologist MDTs based on bacteria and sensitivities. Cases included 20 THR, 13 TKR, 5 Hemiarthroplasties, 4 tibial nonunions, 1 infected femoral plate and 2 paediatric osteomyelitis. Organisms isolated – Coagulase negative Staphs, Staph aureus, MRSA, E coli, Enterococcus, Enterobacter cloacae, Serratia and 1 Salmonella typhimurium!!. In our cases, a combination of Vancomycin and Gentamicin was added to Stimulan beads following manufacturer's mixing guide. In 2 cases, we added Ceftazidime to the beads and Daptomycin in 1 case. In bone infections, surgical debridement and systemic antibiotics were also needed. All arthroplasty infections underwent explantation with addition of antibiotic impregnated beads either at single stage or both stages of 2 stage revisions and systemic antibiotics. Follow up (ranging 9months to 2 years) indicates no failure so far. The beads caused no excessive wound drainage. There was no need to remove beads as they dissolve. In the cases where a staged revision was performed, the beads were inserted at first stage and there was microbiological clearance of infection at 2nd stage. Our series includes some experince in paediatric cases too. As far as we are aware, this is the largest series in the UK from a single centre reporting experience with Stimulan in infected bone and joints of the lower limbs. Our experience suggests use of dissolvable pure Calcium sulphate beads impregnated with carefully selected antibiotics, works as an effective adjunct to current treatments and offers flexibility with choice of antiobiotics that can be added locally. Acknowledgements. Biocomposites UK for supporting attendance at EBJIS. Authors control ownership of all data and analysis

Aim of this work was to evaluate the efficacy of a new antibiotic bone substitute (CERAMENTTM|G) in the treatment of osteomyelitis (OM) in diabetic foot. From June 2013 to April 2015 we used a new Calcium Sulphate Hemihydrate + Hydroxyapatite + Gentamicin Sulfate (CSH + HA + GS) compound to fill resected bone voids following surgical intervention in cases of diabetic foot OM. The uniqueness of this product is that it induces native bone growth, while the synthetic bone disappears and antibiotic is released into the surrounding tissues, maintaining high gentamicin concentrations for some weeks. In 20 patients, with or without Charcot neuroarthropathy and post-lesional osteomyelitis, after removal of infected bone we applied 10 to 20 ml CSH + HA + GS, filling the residual spaces and aiming to stabilize the remaining bone fragments. When needed, these arthrodeses were stabilized by external-internal hybrid fixators. X-ray evaluations and, when indicated, MRI evaluations were performed before and after surgical intervention, and 3 months post-op. Revascularization with percutaneous angioplasty was performed when needed. 20 patients affected by OM were treated, 4 of them having 1st metatarsal head involvement, 4 having heel involvement, 12 tarsal and hindfoot involvement. After surgical intervention all of them were treated with standard medication and pressure relief. The three 1st metatarsal OM cases healed, both in regards to infection and lesions. One of the patients is still ongoing. One of the patients with heel OM presented with a worsening of the infection and was treated by major amputation, another one presented with good soft tissue growth and, two months from the intervention, and in the absence of clinical signs of OM relapse, was treated with a sural fasciocutaneous pedicled flap; of the remaining two patients one heald and the other is still ongoing; 11 of the 12 patients who had midfoot or hindfoot partial resections healed, one patient is still ongoing. The healed patients are all wearing suitable shoes. The use of a new CSH + HA + GS bone substitute has shown to be efficacious in inducing OM healing and preserving foot structures in diabetic feet

Infected nonunion of the femur or tibia diaphysis requires resection of infected bone, stabilization of bone and reconstruction of bone defect. External fixation of the femur is poorly tolerated by patients. In 2004 authors introduced in therapy for infected nonunions of tibia and femur diaphysis coating of IMN with a layer of antibiotic loaded acrylic cement (ALAC) containing 5% of culture specific antibiotic. Seven patients with infected nonunion of the diaphysis of femur (2) and tibia (2) were treated, aged 20–63 years, followed for 2–9 years (average 5,5 years). All have been infected with S. aureus (MSSA: 2 and MRSA: 4) or Staph. epidermidis (1) and in one case with MRSA and Pseudomonas aeruginosa. All patients underwent 3 to 6 operations before authors IMN application. Custom-made IMN coated with acrylic cement (Palamed) loaded fabrically with gentamycin with admixture of 5% of culture-specific antibiotic: vancomycin (7 cases) and meropeneme (1 case) was used for bone stabilization. Static interlocking of IMN was applied in 4 cases and dynamic in 2 cases. In 1 case the femur was stabilized with IMN without interlocking screws. In 2 cases IMN was used for fixation of nonunion at docking site after bone transport. In 3 cases ALAC was used as temporary defect filling and dead space management. In one case after removal of IMN coated with ALAC, a new custom made Gamma nail and tubular bone allograft ranging 11 cm was used for defect reconstruction. Infection healing was achieved in all 7 cases, bone union was achieved in 4 from 7 cases. In 1 case of segmental diaphyseal defect ranging over 12 cm infection was healed, but bone defect was not reconstructed. This patient is waiting for total femoral replacement. In another case of segmental defect of 11 cm infection is healed, but allograft substitution and remodeling by host bone is poor. In the 3rd case of lacking bone healing, the 63 year old patients was noncooperative and not willing to walk in walker with weight bearing. This patient refused further treatment. Custom-made intramedullary nail coated with a layer of acrylic cement loaded with 5% of culture specific antibiotic can provide local infection control, offer comfortable bone stabilization, and replace standard IM nail in therapy for difficult to treat infected diaphyseal nonunion of femur or tibia

Background:. Wide resection of infected bone increases the chances of eradication of infection in patients with chronic osteomyelitis. Aggressive debridement is, however, frequently complicated by the creation of large bone defects. The use of antibiotic-impregnated PMMA spacers, as a customized dead space management tool, has recently grown in popularity. In addition to certain biological advantages, the spacer also offers a therapeutic benefit by serving as a vehicle for delivery of local adjuvant antibiotics. Methods:. This retrospective case series involved 11 patients with chronic osteomyelitis, managed with tibial bone transport through an induced membrane using circular external fixation. All patients were treated according to a standardized treatment protocol and we review the anatomic nature of the disease, the physiological status of the host, the surgical procedures performed, as well as the outcome of treatment in terms of eradication of infection, time to union and the complications that occurred. Results:. Nine patients, with a mean bone defect of 6 cm (range: 2–8 cm) were included in the study. At a mean follow-up of 24 months (range: 14–45 months) eradication of osteomyelitis was achieved in all patients without the need for reoperation for infection. Failure of the skeletal reconstruction occurred in two patients. Six major and four minor complications were experienced. After a mean time of 70 weeks (range: 30 to 104 weeks) in the circular external fixator all but one docking site had united and all regenerated segments were consolidated. Conclusion:. Bone transport, using circular external fixation, through the induced membrane created by the temporary insertion of a PMMA appears to be a useful technique in the management of post-infective tibial bone defects larger than 4 cm in size. Patient selection appears to be a crucial step in ensuring a successful outcome in terms of the resolution of infection

Aims

This study presents patient-reported quality of life (QoL) over the first year following surgical debridement of long bone osteomyelitis. It assesses the bone involvement, antimicrobial options, coverage of soft tissues, and host status (BACH) classification as a prognostic tool and its ability to stratify cases into ‘uncomplicated’ or ‘complex’.